• Published: 13 Sep 2016
  • Incident ID: 3995

Refuelling Hoses left out on the Helideck

Cause & Consequence

  • Other

Other Cause & Consequence


Contributing Factor

  • Complacency

Description of Process

This safety alert is intended to warn Duty Holders of the potential dangers associated with leaving the helicopter fuel hose lying out on the helideck.

Description of Incident

The hose winding mechanism on fuel cabinets can breakdown which makes it difficult to rewind the hose back into the cabinet after a refuelling operation. Consequently helideck teams are leaving the hose laying out around the perimeter of the helideck. This practise MAY be acceptable for a short term pending rectification of the system, PROVIDING an adequate & robust risk assessment is in place and the hose is PROPERLY MANAGED for EVERY helicopter movement. In a recent near miss, a helideck team had left the hose out on deck from a previous refuelling operation. A day or two later when the next helicopter arrived, the hose was left on the downwind side of the helideck which resulted it being under the tail rotor after the helicopter had landed. The helideck team attempted to retrieve the hose but came perilously close to the tail rotor in doing so!

Rewinding the hose back into the cabinet is not just good housekeeping, it has a safety value:

  • When the pump is switched off the hose remains full of fuel so leaving 20-30m of hose out on deck can contribute around 200ltrs of fuel to any incident on the helideck.
  • The hose obscures the green perimeter lights which affects night operations.
  • The hose suffers increased UV degradation & wear dragging across the deck.
  • The hose can end up under the tail rotor putting the helideck team at risk of a rotor strike.

Good Practice Guidance

Because of this near miss and the increasing tendency for installations to leave the hose out on deck; HCA are minded to take a much harder line on instances where the duty holder does not have a satisfactory risk assessment or a suitable rectification plan in place to bring the system back in to compliance promptly, say within 6-months. Upon notification that the system is not operating correctly, HCA will register the system as ‘Non-Compliant’ and issue a Temporary Limitation Notice (TLN) to helicopter Operators advising them of the situation and requiring them not to land with the hose laid downwind. Pilots will be asked to report all such occurrences.

Where a suitable rectification plan is not available, refuelling operations will be suspended until the system is returned to full serviceability.

Contact Details

Helideck Certification Agency Ltd,

Rate this alert

Average Rating

Latest Alerts & Moments

Our searchable catalogue of hundreds of Safety Alerts and Safety Moments are all designed as learning resources that can help improve workplace safety.